Effects of cashew nut shell extract and monensin on in vitro ruminal fermentation, methane production, and ruminal bacterial community.

The objective of this study was to evaluate the effects of cashew nut shell extract (CNSE) and monensin on ruminal in vitro fermentation, CH4 production, and ruminal bacterial community structure. Treatments were as follows: control (CON, basal diet without additives); 2.5 µM monensin (MON); 0.1 mg CNSE granule/g DM (CNSE100); and 0.2 mg CNSE granule/g DM (CNSE200). Each treatment was incubated with 52 mL of buffered ruminal content and 500 mg of total mixed ration for 24 h using serum vials. The experiment was performed as a complete randomized block design with 3 runs. Run was used as a blocking factor. Each treatment had 5 replicates, in which 2 were used to determine nutrient degradability, and 3 were used to determine pH, NH3-N, volatile fatty acids, lactate, total gas, CH4 production, and bacterial community composition. Treatment responses for all data, excluding bacterial abundance, were analyzed with the GLIMMIX procedure of SAS v9.4. Treatment responses for bacterial community structure were analyzed with a PERMANOVA test run with the R package vegan. Orthogonal contrasts were used to test the effects of (1) additive inclusion (ADD: CON vs. MON, CNSE100, and CNSE200); (2) additive type (MCN: MON vs. CNSE100 and CNSE200); and (3) CNSE dose (DOS: CNSE100 vs. CNSE200). We observed that pH, acetate, and acetate:propionate ratio in the CNSE100 treatment were lower compared with CNSE200, and propionate in the CNSE100 treatment was greater compared with CNSE200. Compared with MON, CNSE treatments tended to decrease total lactate concentration. Total gas production of CON was greater by 2.63% compared with all treatments, and total CH4 production was reduced by 10.64% in both CNSE treatments compared with MON. Also, compared with MON, in vitro dry matter degradabilities in CNSE treatments were lower. No effects were observed for NH3-N or in vitro neutral detergent fiber degradability. Finally, the relative abundances of Prevotella, Treponema, and Schwartzia were lower, whereas the relative abundances of Butyrivibrio and Succinivibrio were greater in all treatments compared with CON. Overall, the inclusion of CNSE decreased CH4 production compared with MON, making CNSE a possible CH4 mitigation additive in dairy cattle diets.

Effects of direct-fed microbial supplementation on performance and immune parameters of lactating dairy cows.

We evaluated the effects of supplementing bacterial direct-fed microbial (DFM) on performance, apparent total-tract digestibility, rumen fermentation, and immune parameters of lactating dairy cows. One hundred fourteen multiparous Holstein cows (41 ± 7 DIM) were used in a randomized complete block design with an experiment comprising 14 d of a covariate (pre-experimental sample and data collection) and 91 d of an experimental period. Cows were blocked based on energy-corrected milk (ECM) yield during the covariate period and the following treatments were randomly assigned within each block: (1) control (CON), corn silage-based total mixed ration without DFM; (2) PRO-A, basal diet top-dressed with a mixture of Lactobacillus animalis and Propionibacterium freudenreichii at 3 × 109 cfu/d; and 3) PRO-B, basal diet top-dressed with a mixture of L. animalis, P. freudenreichii, Bacillus subtilis, and Bacillus licheniformis at 11.8 × 109 cfu/d. Milk yield, dry matter intake (DMI), and body weight were measured daily, while milk samples for component analysis were taken on 2 consecutive days of each week of data collection. Feces, urine, rumen, and blood samples were taken during the covariate period, wk 4, 7, 10, and 13 for estimation of digestibility, N-partitioning, rumen fermentation, plasma nutrient status and immune parameters. Treatments had no effect on DMI and milk yield. Fat-corrected milk (3.5% FCM) and milk fat yield were improved with PRO-B, while milk fat percent and feed efficiency (ECM/DMI) tended to increase with PRO-B compared with PRO-A and CON. Crude fat digestibility was greater with PRO-B compared with CON. Feeding CON and PRO-A resulted in higher total volatile fatty acid concentration relative to PRO-B. Percentage of neutrophils tended to be reduced with PRO-A compared with CON and PRO-B. The mean fluorescence intensity (MFI) of anti-CD44 antibody on granulocytes tended to be higher in PRO-B compared with CON. The MFI of anti-CD62L antibody on CD8+ T cells was lower in PRO-A than PRO-B, with PRO-A also showing a tendency to be lower than CON. This study indicates the potential of DFM to improve fat digestibility with consequential improvement in fat corrected milk yield, feed efficiency and milk fat yield by lactating dairy cows. The study findings also indicate that dietary supplementation with DFM may augment immune parameters or activation of immune cells, including granulocytes and T cells; however, the overall effects on immune parameters are inconclusive.

Lactational performance of dairy cows in response to supplementing N-acetyl-l-methionine as source of rumen-protected methionine.

The objective of this experiment was to evaluate the effects of supplementing a rumen-protected source of Met, N-acetyl-l-methionine (NALM), on lactational performance and nitrogen metabolism in early- to mid-lactation dairy cows. Sixty multiparous Holstein dairy cows in early lactation (27 ± 4.3 d in milk, SD) were assigned to 4 treatments in a randomized complete block design. Cows were blocked by actual milk yield. Treatments were as follows: (1) no NALM (control); (2) 15 g/d of NALM (NALM15); (3) 30 g/d of NALM (NALM30); and (4) 45 g/d of NALM (NALM45). Diets were formulated using a Cornell Net Carbohydrate and Protein System (CNCPS) v.6.5 model software to meet or exceed nutritional requirements of lactating dairy cows producing 42 kg/d of milk and to undersupply metabolizable Met (control) or supply incremental amounts of NALM. The digestible Met (dMet) supply for control, NALM15, NALM30, and NALM45 were 54.7, 59.8, 64.7, and 72.2 g/d, respectively. The supply of dMet was 88, 94, 104, and 115% of dMet requirement for control, NALM15, NALM30, and NALM45, respectively. Milk yield data were collected, dry matter intake (DMI) was measured daily, and milk samples were collected twice per week for 22 wk. Blood, ruminal fluid, urine, and fecal samples were collected during the covariate period and during wk 4, 8, and 16. Data were analyzed using the GLIMMIX procedure of SAS (SAS Institute) using covariates in the model for all variables except body weight. Linear, quadratic, and cubic contrasts were also tested. Treatments did not affect DMI, milk yield, and milk component concentration and yield; however, feed efficiency expressed as milk yield per DMI and 3.5% fat-corrected milk per DMI were quadratically affected, with greater response observed for NALM15 and NALM30 compared with control. Acetate proportion linearly increased, whereas propionate proportion linearly decreased with NALM supplementation. Blood urea nitrogen linearly decreased with NALM supplementation. Total plasma essential AA concentrations were quadratically affected, as greater values were observed for control and NALM45 than other treatments. Plasma Met concentration was quadratically affected as lower levels were observed with NALM15, whereas Met concentrations increased with NALM45 compared with control. Nitrogen utilization efficiency and apparent total-tract nutrient digestibility were not affected by treatment. Supplementation of NALM at 15 or 30 g/head per day resulted in the greatest improvements in feed efficiency without affecting N metabolism of early- to mid-lactation dairy cows.

Effects of a xylanase-rich enzyme on intake, milk production, and digestibility of dairy cows fed a diet containing a high proportion of bermudagrass silage.

We previously reported that milk production in dairy cows was increased by adding a specific xylanase-rich exogenous fibrolytic enzyme (XYL) to a total mixed ration (TMR) containing 10% bermudagrass silage (BMD). Two follow-up experiments were conducted to examine whether adding XYL would increase the performance of dairy cows consuming a TMR containing a higher (20%) proportion of BMD (Experiment 1) and to evaluate the effects of XYL on in vitro fermentation and degradability of the corn silage, BMD, and TMR (Experiment 2). In Experiment 1, 40 lactating Holstein cows in early lactation (16 multiparous and 24 primiparous; 21 ± 3 d in milk; 589 ± 73 kg of body weight) were blocked by milk yield and parity and randomly assigned to the Control and XYL treatments. The TMR contained 20% BMD, 25% corn silage, 8% wet brewer's grain, and 47% concentrate mixture in the dry matter (DM). Cows were fed the XYL-treated or untreated experimental TMR twice per day for 10 wk after a 9-d covariate period. In Experiment 2, ruminal fluid was collected from 3 cannulated lactating Holstein cows fed a diet containing 20% bermudagrass haylage, 25% corn silage and 55% concentrate. In Experiment 1, compared with Control, application of XYL did not affect DM intake (24.0 vs. 23.7 kg/d), milk yield (35.1 vs. 36.2 kg/d), fat-corrected milk yield (36.1 vs. 36.9 kg/d), or yields of milk fat (1.29 vs. 1.31 kg/d) or protein (1.07 vs. 1.08 kg/d). However, intake of neutral detergent fiber (4.67 vs. 4.41 kg/d) tended to increase with XYL; consequently, milk protein concentration was increased by XYL (3.02 vs. 2.95%). Feed efficiency tended to be lower in cows fed XYL (1.57 vs. 1.52 kg of fat-corrected milk/kg of DM intake) compared with Control. In Experiment 2, XYL tended to increase the rate of gas production in the TMR, the molar proportion of propionate for corn silage, and that of valerate for the TMR. In addition, XYL increased in vitro DM, neutral detergent fiber, and acid detergent fiber degradability of BMD and corn silage. Application of XYL to a diet with a relatively high proportion of BMD tended to increase digestible neutral detergent fiber intake, increased milk protein concentration, and in vitro degradability of DM, neutral detergent fiber, and acid detergent fiber. However, XYL did not affect milk production and tended to decrease feed efficiency in early lactation cows.

Short communication: Effects of a physiologically relevant concentration of aflatoxin B1 with or without sequestering agents on in vitro rumen fermentation of a dairy cow diet.

Aflatoxin is a potent carcinogen commonly found in animal feeds that can impair rumen fermentation at high concentrations; however, its effects at physiologically relevant concentrations are unknown. This study examined the effects of aflatoxin B1 (AFB1), with or without bentonite clay (CL) and Saccharomyces cerevisiae fermentation product (SCFP)-based sequestering agents on in vitro rumen fermentation and digestibility of a dairy cow TMR. Corn silage-based TMR (0.5 g, 17.3% crude protein and 1.67 Mcal/kg of net energy for lactation) was incubated in a rumen fluid-buffer inoculum (1:2 ratio; 50 mL) with the following treatments: (1) no additives (control); (2) control + 0.75 µg/L AFB1 (T); (3) T + 80 mg/L sodium bentonite clay (CL; Astra-Ben-20, Prince Agri Products Inc., Quincy, IL); or (4) CL + 14 mg/L SCFP (CL+SCFP; Diamond V, Cedar Rapids, IA). Ruminal fluid was collected 3 h after the morning feeding from 3 cannulated cows fed the same TMR, and rumen fluid from individual cows was used to prepare separate inocula. Each treatment was incubated in duplicate at 39°C for 0, 4, 8, 16, and 24 h in each of 3 runs. Adding T reduced total volatile fatty acid (VFA) concentration after 4 and 8 h and molar proportion of propionate after 4 and 24 h of incubation relative to control. Adding sequestering agents (CL and CL+SCFP) with T did not affect total VFA concentration after 4 or 8 h, but increased total VFA after 16 h and tended to increase molar proportion of propionate after 24 h compared with T. At 24 h, T had lower DM digestibility and higher NH3-N concentration compared with the control. Thus, AFB1, even at very low concentration (0.75 µg/L), had detrimental effects on rumen fermentation and subsequently DM digestibility of the TMR. Adding sequestering agents did not prevent negative effects of T on rumen fermentation within 8 h of incubation; however, sequestering agents were effective after 16 h of incubation.

Effect of sequestering agents based on a Saccharomyces cerevisiae fermentation product and clay on the ruminal bacterial community of lactating dairy cows challenged with dietary aflatoxin B1.

This study was conducted to examine the effects of clay (CL) and Saccharomyces cerevisiae fermentation product (SCFP) on the ruminal bacterial community of Holstein dairy cows challenged with aflatoxin B1 (AFB1). A second objective was to examine correlations between bacterial abundance and performance measures. Eight lactating dairy cows stratified by milk yield and parity were randomly assigned to 4 treatments in a 4 × 4 Latin square design with 2 replicate squares, four 33-d periods, and a 5-d washout between periods. The treatments included (1) control (basal diet, no additive); (2) T (control + 63.4 µg/kg AFB1, oral dose); (3) CL (T + 200 g/head per day of sodium bentonite clay, top-dress); and (4) CL+SCFP [CL + 19 g/head per day Diamond V NutriTek (Diamond V Inc., Cedar Rapids, IA) + 16 g/head per day MetaShield (Diamond V Inc.), top-dress]. Cows were adapted to diets containing no AFB1 from d 1 to 25 (predosing period). From d 26 to 30 (dosing period), AFB1 was orally dosed and then withdrawn for d 31 to 33 (withdrawal period). During the predosing period, compared with the control, feeding CL and CL+SCFP increased the relative abundance of the most dominant phylum, Bacteroidetes (55.1 and 55.8 vs. 50.6%, respectively), and feeding CL+SCFP increased Prevotella abundance (43.3 and 43.6 vs. 40.0%, respectively). During the dosing period, feeding AFB1 did not affect the ruminal bacterial community, but the relative abundance of Fibrobacteraceae increased with CL+SCFP compared with T (1.45 vs. 0.97%); Fibrobacter abundance also tended to increase with CL+SCFP compared with T and control, respectively (1.45 vs. 0.97 and 1.05%, respectively). Feeding AFB1 with or without CL or CL+SCFP did not affect ruminal pH or concentrations of NH3-N, total volatile fatty acids, or individual volatile fatty acids. Milk yield and milk component yields were positively correlated with the relative abundance of unclassified Succinivibrionaceae, unclassified YS2, or Coprococcus. Feed efficiency was positively correlated (r ≥ 0.30) with the relative abundance of unclassified YS2, Coprococcus, or Treponema. Feeding aflatoxin at 63 µg/kg, a common contamination level on farms, did not affect the abundance of dominant bacteria or rumen fermentation. When aflatoxin was fed, CL+SCFP increased the abundance of Fibrobacter, a major fibrolytic bacteria genus. Milk yield and DMI were positively correlated with abundance of Succinivibrionaceae and Coprococcus. Feed efficiency was positively correlated with abundance of Coprococcus, Treponema, and YS2. Future studies should speciate culture and determine the functions of the bacteria to elucidate their roles in the rumen and potential contribution to increasing the performance of dairy cows.

Symposium review: Technologies for improving fiber utilization.

The forage lignocellulosic complex is one of the greatest limitations to utilization of the nutrients and energy in fiber. Consequently, several technologies have been developed to increase forage fiber utilization by dairy cows. Physical or mechanical processing techniques reduce forage particle size and gut fill and thereby increase intake. Such techniques increase the surface area for microbial colonization and may increase fiber utilization. Genetic technologies such as brown midrib mutants (BMR) with less lignin have been among the most repeatable and practical strategies to increase fiber utilization. Newer BMR corn hybrids are better yielding than the early hybrids and recent brachytic dwarf BMR sorghum hybrids avoid lodging problems of early hybrids. Several alkalis have been effective at increasing fiber digestibility. Among these, ammoniation has the added benefit of increasing the nitrogen concentration of the forage. However, few of these have been widely adopted due to the cost and the caustic nature of the chemicals. Urea treatment is more benign but requires sufficient urease and moisture for efficacy. Ammonia-fiber expansion technology uses high temperature, moisture, and pressure to degrade lignocellulose to a greater extent than ammoniation alone, but it occurs in reactors and is therefore not currently usable on farms. Biological technologies for increasing fiber utilization such as application of exogenous fibrolytic enzymes, live yeasts, and yeast culture have had equivocal effects on forage fiber digestion in individual studies, but recent meta-analyses indicate that their overall effects are positive. Nonhydrolytic expansin-like proteins act in synergy with fibrolytic enzymes to increase fiber digestion beyond that achieved by the enzyme alone due to their ability to expand cellulose microfibrils allowing greater enzyme penetration of the cell wall matrix. White-rot fungi are perhaps the biological agents with the greatest potential for lignocellulose deconstruction, but they require aerobic conditions and several strains degrade easily digestible carbohydrates. Less ruminant nutrition research has been conducted on brown rot fungi that deconstruct lignocellulose by generating highly destructive hydroxyl radicals via the Fenton reaction. More research is needed to increase the repeatability, efficacy, cost effectiveness, and on-farm applicability of technologies for increasing fiber utilization.

Effects of homolactic bacterial inoculant on the performance of lactating dairy cows.

The objective of this experiment was to determine the effect of applying a homofermentative bacterial inoculant to corn silage on the performance of dairy cows. After harvesting, corn forage was treated with nothing (CON) or with an inoculant containing a mixture of Lactococcus lactis, Lactobacillus plantarum, and Enterococcus faecium at 1.5 × 105 cfu/g of fresh forage (MC; SiloSolve MC, Chr. Hansen A/S, Hørsholm, Denmark). After 186 d of storage in Ag-Bags (A Miller-St. Nazianz Inc., St. Nazianz, WI), silages were fed as part of a total mixed ration containing 55% concentrates, 10% alfalfa hay, and 35% CON or MC corn silage. Sixty early-lactation Holstein dairy cows (30 multiparous and 30 primiparous) housed in a freestall barn with Calan gates (American Calan Inc., Northwood, NH) were assigned to the dietary treatments from 20 to 100 d in milk. Silage inoculated with MC had a more homofermentative pattern evidenced by greater lactic acid concentration (3.83 vs. 4.48% of DM) and lower concentrations of acetic (2.34 vs. 1.68% of DM) and propionic (0.37 vs. 0.10% of DM) acids and ammonia (9.11 vs. 7.82% of N) for CON and MC, respectively. Dry matter intake (23.1 vs. 23.2 kg/d) did not differ among treatments, but the MC silage had greater apparent digestibility of DM (68.8 vs. 70.8%), which led to greater yields of milk (37.7 vs. 38.5 kg/d), fat-corrected milk (37.6 vs. 38.4 kg/d), milk fat (1.30 vs. 1.33 kg/d), and lactose (1.83 vs. 1.92 kg/d) for CON and MC cows, respectively. Milk from cows fed MC silage had higher lactose (4.86 vs. 4.93%), lower protein (2.93 vs. 2.83%), and similar contents of fat (3.47 vs. 3.44%) compared with CON cows. Feed efficiency (fat-corrected milk/dry matter intake) was not affected by treatment (1.69 vs. 1.72 for CON and MC, respectively). Inoculation of corn silage with the homofermentative inoculant increased digestibility of the total mixed ration and increased milk yield by lactating dairy cows.

Effect of adding clay with or without a Saccharomyces cerevisiae fermentation product on the health and performance of lactating dairy cows challenged with dietary aflatoxin B1.

The study was conducted to examine the effect of supplementing bentonite clay with or without a Saccharomyces cerevisiae fermentation product (SCFP; 19 g of NutriTek + 16 g of MetaShield, both from Diamond V, Cedar Rapids, IA) on the performance and health of dairy cows challenged with aflatoxin B1 (AFB1). Twenty-four lactating Holstein cows (64 ± 11 d in milk) were stratified by parity and milk production and randomly assigned to 1 of 4 treatment sequences. The experiment had a balanced 4 × 4 Latin square design with 6 replicate squares, four 33-d periods, and a 5-d washout interval between periods. Cows were fed a total mixed ration containing 36.1% corn silage, 8.3% alfalfa hay, and 55.6% concentrate (dry matter basis). Treatments were (1) control (no additives), (2) toxin (T; 1,725 µg of AFB1/head per day), (3) T + clay (CL; 200 g/head per day; top-dressed), and (4) CL+SCFP (CL+SCFP; 35 g/head per day; top-dressed). Cows were adapted to diets from d 1 to 25 (predosing period) and then orally dosed with AFB1 from d 26 to 30 (dosing period), and AFB1 was withdrawn from d 31 to 33 (withdrawal period). Milk samples were collected twice daily from d 21 to 33, and plasma was sampled on d 25 and 30 before the morning feeding. Transfer of ingested AFB1 into milk aflatoxin M1 (AFM1) was greater in T than in CL or CL+SCFP (1.65 vs. 1.01 and 0.94%, respectively) from d 26 to 30. The CL and CL+SCFP treatments reduced milk AFM1 concentration compared with T (0.45 and 0.40 vs. 0.75 µg/kg, respectively), and, unlike T, both CL and CL+SCFP lowered AFM1 concentrations below the US Food and Drug Administration action level (0.5 µg/kg). Milk yield tended to be greater during the dosing period in cows fed CL+SCFP compared with T (39.7 vs. 37.7 kg/d). Compared with that for T, plasma glutamic oxaloacetic transaminase concentration, indicative of aflatoxicosis and liver damage, was reduced by CL (85.9 vs. 95.2 U/L) and numerically reduced by CL+SCFP (87.9 vs. 95.2 U/L). Dietary CL and CL+SCFP reduced transfer of dietary AFB1 to milk and milk AFM1 concentration. Only CL prevented the increase in glutamic oxaloacetic transaminase concentration, and only CL+SCFP prevented the decrease in milk yield caused by AFB1 ingestion.

Effects of the dose and viability of Saccharomyces cerevisiae. 2. Ruminal fermentation, performance of lactating dairy cows, and correlations between ruminal bacteria abundance and performance measures.

This study examined effects of the dose and viability of supplemented Saccharomyces cerevisiae yeast strain YE1496 on ruminal fermentation and performance of lactating dairy cows. A second objective was to examine correlations between ruminal bacteria abundance and performance measures. Four ruminally cannulated lactating cows (284 ± 18 days in milk) were assigned randomly to 1 of 4 treatment sequences in a 4 × 4 Latin square experimental design using four 21-d experimental periods. Cows were fed a nonacidotic total mixed ration comprising 22.5% starch (minimum ruminal pH >5.8), 41.7% corn silage, 7.60% wet brewers grain, and 50.7% concentrate on a dry matter (DM) basis. The diet was supplemented with no yeast (control), a low (5.7 × 107 cfu/d; LLY) or high (6.0 × 108 cfu/d; HLY) dose of live yeast, or a high dose of killed yeast (6.0 × 108 cfu/d; killed by heating at 80°C for 1.5 h; HDY). Milk production and composition were measured twice daily from d 11 to 21 of each period, and rumen fluid samples were collected on d 21. In vivo digestibility was measured using chromic oxide as a marker. Pearson correlation analysis was used to assess whether animal performance parameters were correlated with relative abundance (RA) of ruminal bacteria. Supplemental LLY increased yields (kg/d) of milk (29.6 vs. 31.7) and milk protein (0.95 vs. 1.03), tended to increase milk fat yield (1.10 vs. 1.17) and ruminal acetate:propionate ratio (1.92 vs. 2.21), and increased in vivo apparent digestibility (%) of DM (64.5 vs. 69.1), neutral detergent fiber (NDF; 45.0 vs. 54.5), and ADF (53.1 vs. 60.9) compared with the control. Feeding HLY had no effects on milk yield compared with the control (30.0 vs. 29.6 kg/d). Feeding HDY tended to increase in vivo digestibility (%) of NDF (45.0 vs. 50.7), ADF (53.1 vs. 57.7), and the ruminal concentration of lactate (0.78 vs. 2.82 mM) but did not affect milk yield compared with the control. Dry matter and NDF digestibility correlated negatively with RA of unclassified Lachnospiraceae in both solid (r = -0.50 and -0.52, respectively) and liquid (r = -0.56 and -0.57, respectively) fractions, whereas milk yield correlated positively with RA of Lachnospiraceae [Ruminococcus] (an incompletely classified genus; r = 0.43) in the solid ruminal fraction. Supplemental LLY, HLY, or HDY increased or tended to increase DM, NDF, and ADF digestibility, but only LLY increased yields of milk, milk fat, and milk protein.

Fate of Escherichia coli O157:H7 and bacterial diversity in corn silage contaminated with the pathogen and treated with chemical or microbial additives.

Inhibiting the growth of Escherichia coli O157:H7 (EC) in feeds may prevent the transmission or cycling of the pathogen on farms. The first objective of this study was to examine if addition of propionic acid or microbial inoculants would inhibit the growth of EC during ensiling, at silo opening, or after aerobic exposure. The second objective was to examine how additives affected the bacterial community composition in corn silage. Corn forage was harvested at approximately 35% dry matter, chopped to a theoretical length of cut of 10 mm, and ensiled after treatment with one of the following: (1) distilled water (control); (2) 1 × 105 cfu/g of EC (ECCH); (3) EC and 1 × 106 cfu/g of Lactobacillus plantarum (ECLP); (4) EC and 1 × 106 cfu/g of Lactobacillus buchneri (ECLB); and (5) EC and 2.2 g/kg (fresh weight basis) of propionic acid, containing 99.5% of the acid (ECA). Each treatment was ensiled in quadruplicate in laboratory silos for 0, 3, 7, and 120 d and analyzed for EC, pH, and organic acids. Samples from d 0 and 120 were also analyzed for chemical composition. Furthermore, samples from d 120 were analyzed for ammonia N, yeasts and molds, lactic acid bacteria, bacterial community composition, and aerobic stability. The pH of silages from all treatments decreased below 4 within 3 d of ensiling. Escherichia coli O157:H7 counts were below the detection limit in all silages after 7 d of ensiling. Treatment with L. buchneri and propionic acid resulted in fewer yeasts and greater aerobic stability compared with control, ECCH, and ECLP silages. Compared with the control, the diversity analysis revealed a less diverse bacterial community in the ECLP silage and greater abundance of Lactobacillus in the ECLP and ECA silages. The ECLB silage also contained greater abundance of Acinetobacter and Weissella than other silages. Subsamples of silages were reinoculated with 5 × 105 cfu/g of EC either immediately after silo opening or after 168 h of aerobic exposure, and EC were enumerated after 6 or 24 h, respectively. All silages reinoculated with EC immediately after silo opening (120 h) had similar low pH values (<4.0) and EC counts were below the detection limit. The ECCH and ECLP silages reinoculated with EC after 168 h of aerobic exposure had relatively high pH values (>5.0) and EC counts (5.39 and 5.30 log cfu/g, respectively) 24 h later. However, those treated with L. buchneri or propionic acid had lower pH values (4.24 or 3.96, respectively) and lower EC counts (1.32 log cfu/g or none, respectively). During ensiling, EC was eliminated from all silages at pH below 4.0. During aerobic exposure, the growth of EC was reduced or prevented in silages that had been treated with L. buchneri or propionic acid at ensiling, respectively.

Effects of maturity at ensiling of bermudagrass and fibrolytic enzyme application on the performance of early-lactation dairy cows.

The objective of this study was to examine effects of adding fibrolytic enzymes to diets containing bermudagrass ensiled after 4 or 7wk of regrowth on the diet digestibility, ruminal fermentation and performance of lactating cows, and the interaction of the treatments. In experiment 1, 64 Holstein cows (22±4d in milk) were assigned to an experiment with a 2×2 factorial treatment arrangement and a 56-d duration. Treatments were diets containing 4 or 7wk regrowth bermudagrass silage without or with an exogenous fibrolytic enzyme cocktail. The cellulase-xylanase enzyme was applied at 2.33g/kg of total mixed ration dry matter (DM) during mixing immediately before feeding. Experiment 2 was aimed at examining treatment effects on the ruminal fermentation profile. Four ruminally cannulated cows were assigned to the 4 treatments using a 4×4 Latin square design with 14-d periods. No enzyme by maturity interaction was detected for any measurement. Regardless of forage maturity, applying the fibrolytic enzyme did not affect DM intake, milk yield, apparent digestibility, feed efficiency, energy balance, and ruminal fermentation though it tended to increase milk lactose concentration (4.88 vs. 4.81%). Feeding the 4-wk diet instead of the 7-wk diet increased DM intake (22.4 vs. 21.3kg/d), digestibility of DM, neutral detergent fiber, and acid detergent fiber, and tended to increase 3.5%-fat corrected milk yield (47.2 vs. 44.3kg/d) and milk fat yield (1.88 vs. 1.73kg/d). Therefore, daily intake of net energy and secretion of milk energy were greater for the 4-wk diet. In addition, the 4-wk diet increased the ruminal concentrations of acetate, propionate, valerate, lactate, and total volatile fatty acids, and decreased ruminal pH, without affecting the acetate:propionate ratio. Feeding fibrolytic enzymes did not improve the performance of early-lactation dairy cows, but harvesting the forage earlier tended to improve milk production.

Effects of genotype, wilting, and additives on the nutritive value and fermentation of bermudagrass silage.

Bermudagrass is the main warm-season grass species used for livestock production in the southeastern United States; however, when it is ensiled, the silage fermentation parameters are often less than desirable. The objective of this study was to investigate the effects of management practices on the nutritive value and fermentation characteristics of bermudagrass silage. In Exp. 1, treatments were the factorial combinations of 2 bermudagrass genotypes, 'Jiggs' () and 'Tifton 85' ( sp.), 4 additives, and 2 DM concentrations at ensiling. The additives were 1) untreated control (deionized water), 2) Ecosyl, 3) B500, or 4) sugarcane molasses. The 2 DM concentrations at ensiling were low DM (22% DM) or high DM (53% DM). Treatments were replicated 3 times in a completely randomized design. Silage treated with molasses had a lesser ( < 0.05) pH and greater ( < 0.01) lactate concentrations than the control, Ecosyl, and B500 in silage with low DM concentrations and greater ( < 0.01) in vitro true digestibility (IVTD) and lesser ( < 0.01) ADF concentrations than the other treatments at either DM concentration. Silage treated with B500 had the greatest ( < 0.01) aerobic stability, whereas that treated with molasses had the least aerobic stability. However, all treatments presented long aerobic stability (≥150 h). Jiggs had lesser ( < 0.01) ADF and NDF and NDF digestibility (NDFD) concentrations than Tifton 85 and Tifton 85 had greater ( < 0.01) IVTD than Jiggs in the silage with a high DM concentration. In Exp. 2, Jiggs silage treated with either molasses (20 g molasses [DM]/kg forage [as-fed basis]) or nothing (control, untreated silage) was fed to 16 beef heifers ( sp.) in individual drylot pens in a completely randomized design with 8 replicates for voluntary DMI, in vivo apparent DM digestibility, and NDFD evaluations. There were no differences ( = 0.36) among treatments in NDFD; however, there was a trend ( < 0.08) for greater in vivo apparent DM digestibility and DMI in heifers fed the molasses-treated silage. Microbial inoculants had decreased effects on Jiggs and Tifton 85 bermudagrass silage ensiled at a low DM concentration; however, adding molasses was an effective management practice to improve its nutritive value and fermentation characteristics.

Effects of 3 sequestering agents on milk aflatoxin M1 concentration and the performance and immune status of dairy cows fed diets artificially contaminated with aflatoxin B1.

This study examined whether adding 3 mycotoxin-sequestering agents to diets contaminated with aflatoxin B1 (AFB1) would reduce milk aflatoxin M1 (AFM1) concentration, and improve the performance and alter immune status of dairy cows. Fifteen lactating dairy cows were used in an experiment with an incomplete crossover design including four 28-d periods. Treatments included a control diet (C), a toxin diet (T; 1,725µg of AFB1/head per day; 75µg/kg), and diets containing the toxin and 20g/head per day of a proprietary mixture of Saccharomyces cerevisiae fermentation product containing a low (SEQ1) or high (SEQ2) dose of a chlorophyll-based additive, or a low dose of the chlorophyll-based additive and sodium bentonite clay (SEQ3). Sequestering agents were top-dressed on the total mixed ration (TMR) daily in each period, and AFB1 was dosed orally in gelatin capsules before the TMR was fed on d 21 to 25. Milk was sampled twice daily on d 20 to 28 and plasma was sampled on d 20 and 25. Sequestering agents did not affect milk AFM1 concentration during the toxin-dosing period. However, after AFB1 was withdrawn, the sequestering agents reduced the time required (24 vs. 48h) to reduce the milk AFM1 concentration below the Food and Drug Administration action level of 0.5µg/kg. Feeding T instead of C tended to reduce milk and fat-corrected milk yields, but feeding SEQ1 prevented these effects. Red blood cell count and hemoglobin concentration were reduced by feeding T instead of C, but not by feeding SEQ1, SEQ2, or SEQ3. The mean fluorescence intensity of antibody staining for 2 leukocyte adhesion molecules, L-selectin (CD62L) and ß-integrin (CD18), tended to be greatest when SEQ1 and SEQ3 were fed. Plasma acid-soluble protein concentration was decreased by feeding SEQ1, SEQ2, and SEQ3 instead of T. Sequestering agents had no effect on milk AFM1 concentration, but they reduced the time required to reduce milk AFM1 concentration to a safe level after withdrawal of AFB1 from the diet. Only SEQ1 prevented the adverse effects of AFB1 on milk and fat-corrected milk yields.

Screening exogenous fibrolytic enzyme preparations for improved in vitro digestibility of bermudagrass haylage.

Our objectives were to evaluate the effects of 12 exogenous fibrolytic enzyme products (EFE) on ruminal in vitro neutral detergent fiber digestibility (NDFD) and preingestive hydrolysis of a 4-wk regrowth of bermudagrass haylage (BH), to examine the accuracy of predicting NDFD with EFE activity measures, and to examine the protein composition of the most and least effective EFE at increasing NDFD. In experiment 1, effects of 12 EFE on NDFD of BH were tested. Enzymes were applied in quadruplicate to culture tubes containing ground BH. The suspension was incubated for 24 h at 25 °C before addition of rumen fluid media and further incubation for 24 h at 39 °C. The experiment was repeated twice. In addition, regression relationships between EFE activity measures and NDFD were examined. Compared with the values for the control, 9 EFE-treated substrates had greater NDFD (37.8 to 40.4 vs. 35.6%), 6 had greater total VFA concentration (59.1 to 61.2 vs. 55.4 mM), and 4 had lower acetate-to-propionate ratios (3.03 to 3.16 vs. 3.24). In experiment 2, EFE effects on preingestive fiber hydrolysis were evaluated by incubating enzyme-treated and untreated bermudagrass suspensions in quadruplicate for 24 h at 25 °C and examining fiber hydrolysis measures. Compared with values for the control, 3 EFE reduced neutral detergent fiber concentration (62.8 to 63.7 vs. 67.3%), 10 increased release of water-soluble carbohydrates (26.8 to 58.5 vs. 22.8 mg/g), and 8 increased release of ferulic acid (210 to 391 vs. 198 µg/g). Regression analyses revealed that enzyme activities accurately [coefficient of determination (R(2)) = 0.98] predicted preingestive hydrolysis measures (water-soluble carbohydrates, ferulic acid), moderately (R(2) = 0.47) predicted neutral detergent fiber hydrolysis, but poorly (R(2) ≤ 0.1) predicted dry matter and NDFD. In experiment 3, proteomic tools were used to examine the protein composition of the most and least effective EFE at improving NDFD. Relative to the least effective, the most effective EFE at increasing NDFD contained 10 times more endoglucanase III, 17 times more acetylxylan esterase with a cellulose-binding domain 1, 33 times more xylanase III, 25 times more ß-xylosidase, and 7.7 times more polysaccharide monooxygenase with cellulose-binding domain 1 and 3 times more swollenin. The most effective EFE had a much greater quantity of fibrolytic enzymes and key proteins necessary for hemicellulose and lignocellulase deconstruction. This study identified several EFE that increased the NDFD and in vitro fermentation of 4-wk BH and revealed why some EFE are more effective than others.

Effect of microbial inoculants on the quality and aerobic stability of bermudagrass round-bale haylage.

The objective of this study was to compare the efficacy of using 4 commercially available microbial inoculants to improve the fermentation and aerobic stability of bermudagrass haylage. We hypothesized that the microbial inoculants would increase the fermentation and aerobic stability of the haylages. Bermudagrass (4-wk regrowth) was harvested and treated with (1) deionized water (control); (2) Buchneri 500 (B500; Lallemand Animal Nutrition, Milwaukee, WI) containing 1×10(5) of Pediococcus pentosaceus and 4×10(5) of Lactobacillus buchneri 40788; (3) Biotal Plus II (BPII; Lallemand Animal Nutrition) containing 1.2×10(5) of P. pentosaceus and Propionibacteria freudenreichii; (4) Silage Inoculant II (SI; AgriKing Inc., Fulton, IL) containing 1×10(5) of Lactobacillus plantarum and P. pentosaceus; and (5) Silo King (SK; AgriKing Inc.), containing 1×10(5) of L. plantarum, Enterococcus faecium, and P. pentosaceus, respectively. Forty round bales (8 per treatment; 441±26kg; 1.2×1.2 m diameter) were made and each was wrapped with 7 layers of plastic. Twenty bales were stored for 112 d and the remaining 20 were stored for 30 d and sampled by coring after intermediary storage periods of 0, 3, 7, and 30 d. The pH of control and inoculated haylages sampled on d 3 did not differ. However, B500 and BPII had lower pH (5.77±0.04 vs. 6.16±0.04; 5.06±0.13 vs. 5.52±0.13) than other treatments by d 7 and 30, respectively. At final bale opening on d 112, all treatments had lower pH than the control haylage (4.77±0.07 vs. 5.37±0.07). The B500, BPII, and SI haylages had greater lactic acid and lactic-to-acetic acid ratios than SK and control haylages. No differences were detected in neutral detergent fiber digestibility, dry matter losses, dry matter, lactic and acetic acid concentrations, and yeast and coliform counts. The SK haylage had lower clostridia counts compared with the control (1.19±0.23 vs. 1.99±0.23 cfu/g). Treatments B500, BPII, SI, and SK tended to reduce mold counts and they improved aerobic stability by 236, 197, 188, and 95%, respectively, compared with the control (276±22 vs. 99±22h).

Ruminant Nutrition Symposium: Improving cell wall digestion and animal performance with fibrolytic enzymes.

This paper aimed to summarize published responses to treatment of cattle diets with exogenous fibrolytic enzymes (EFE), to discuss reasons for variable EFE efficacy in animal trials, to recommend strategies for improving enzyme testing and EFE efficacy in ruminant diets, and to identify proteomic differences between effective and ineffective EFE. A meta-analysis of 20 dairy cow studies with 30 experiments revealed that only a few increased lactational performance and the response was inconsistent. This variability is attributable to several enzyme, feed, animal, and management factors that were discussed in this paper. The variability reflects our limited understanding of the synergistic and sequential interactions between exogenous glycosyl hydrolases, autochthonous ruminal microbes, and endogenous fibrolytic enzymes that are necessary to optimize ruminal fiber digestion. An added complication is that many of the standard methods of assaying EFE activities may over- or underestimate their potential effects because they are based on pure substrate saccharification and do not simulate ruminal conditions. Our recent evaluation of 18 commercial EFE showed that 78 and 83% of them exhibited optimal endoglucanase and xylanase activities, respectively, at 50 °C, and 77 and 61% had optimal activities at pH 4 to 5, respectively, indicating that most would likely act suboptimally in the rumen. Of the many fibrolytic activities that act synergistically to degrade forage fiber, the few usually assayed, typically endoglucanase and xylanase, cannot hydrolyze the recalcitrant phenolic acid-lignin linkages that are the main constraints to ruminal fiber degradation. These factors highlight the futility of random addition of EFE to diets. This paper discusses reasons for the variable animal responses to dietary addition of fibrolytic enzymes, advances explanations for the inconsistency, suggests a strategy to improve enzyme efficacy in ruminant diets, and describes differences among the proteomes of effective and ineffective EFE.

Effects of 8 chemical and bacterial additives on the quality of corn silage.

This project aimed to evaluate the effects 8 additives on the fermentation, dry matter (DM) losses, nutritive value, and aerobic stability of corn silage. Corn forage harvested at 31% DM was chopped (10mm) and treated with (1) deionized water (control); (2) Buchneri 500 (BUC; 1×10(5) cfu/g of Pediococcus pentosaceus 12455 and 4×10(5) cfu/g of Lactobacillus buchneri 40788; Lallemand Animal Nutrition, Milwaukee, WI); (3) sodium benzoate (BEN; 0.1% of fresh forage); (4) Silage Savor acid mixture (SAV: 0.1% of fresh forage; Kemin Industries Inc., Des Moines, IA); (5) 1×10(6) cfu/g of Acetobacter pasteurianus-ATCC 9323; (6) 1×10(6) cfu/g of Gluconobacter oxydans-ATCC 621; (7) Ecosyl 200T (1×10(5) cfu/g of Lactobacillus plantarum MTD/1; Ecosyl Products Inc., Byron, IL); (8) Silo-King WS (1.5×10(5) cfu/g of L. plantarum, P. pentosaceus and Enterococcus faecium; Agri-King, Fulton, IL); and (9) Biomax 5 (BIO; 1×10(5) cfu/g of L. plantarum PA-28 and K-270; Chr. Hansen Animal Health and Nutrition, Milwaukee, WI). Treated forage was ensiled in quadruplicate in mini silos at a density of 172 kg of DM/m(3) for 3 and 120 d. After 3 d of ensiling, the pH of all silages was below 4 but ethanol concentrations were least in BEN silage (2.03 vs. 3.24% DM) and lactic acid was greatest in SAV silage (2.97 vs. 2.51% DM). Among 120-d silages, additives did not affect DM recovery (mean=89.8% ± 2.27) or in vitro DM digestibility (mean=71.5% ± 0.63). The SAV silage had greater ammonia-N (0.85 g/kg of DM) and butyric acid (0.22 vs. 0.0% DM) than other treatments. In contrast, BEN and Silo-King silages had the least ammonia-N concentration and had no butyric acid. The BEN and A. pasteurianus silages had the lowest pH (3.69) and BEN silage had the least ethanol (1.04% DM) and ammonia nitrogen (0.64 g/kg DM) concentrations, suggesting that fermentation was more extensive and protein degradation was less in BEN silages. The BUC and BIO silages had greater acetic acid concentrations than control silages (3.19 and 3.19 vs. 2.78% DM), but yeast counts did not differ. Aerobic stability was increased by 64% by BUC (44.30 h) and by 35% by BEN (36.49 h), but other silages had similar values (27.0±1.13 h).

Effect of a dual-purpose inoculant on the quality and nutrient losses from corn silage produced in farm-scale silos.

This project aimed to determine effects of applying an inoculant containing homofermentative and heterofermentative bacteria on the fermentation, nutritive value, aerobic stability, and nutrient losses from corn silage produced in farm-scale silos. Corn forage was harvested at 34% dry matter (DM) and treated without (control) or with 5 × 105 cfu/g of Lactobacillus buchneri and Pediococcus pentosaceus. The inoculant was sprayed on alternate 8-row-wide swaths of forage, and the untreated and inoculated forages were alternately packed into 3.6-m-wide bag silos. Forty-five tonnes of corn forage were packed into each of 4 replicate bags per treatment and ensiled for 166 d. Silage removed from the bags (500 kg/d) was separated into good and spoiled (visibly moldy or darker) silage portions, and weighed for 35 d. Weekly composites were analyzed for chemical composition, aerobic stability, and fungal counts. Aerobic stability was measured using data loggers that recorded sample and ambient temperature every 30 min for 7 d. Inoculation did not affect the chemical composition of the spoiled or good silage but decreased the quantity (5.7 vs. 12.9 kg/d) and percentage (3.4 vs. 7.8) of spoiled silage in the bags by over 50%. Losses of crude protein (0.28 vs. 0.92 kg/d), gross energy (6.0 × 104 vs. 1.8 × 105 kJ/d), and neutral detergent fiber (1.34 vs. 4.12 kg/d) in spoiled silage were less in inoculated versus control silages. Inoculated silages had lower pH (3.91 vs. 3.99), lactate concentration (7.63 vs. 7.86%), lactate:acetate ratio (1.58 vs. 2.53%), and a greater acetate (5.11 vs. 3.56%) concentration than the control silage. Inoculated silages tended to have fewer yeasts (2.59 vs. 4.62 log cfu/g) than control silages, but aerobic stability was not different across treatments (14.7 vs. 9.5 h). Applying the inoculant made the fermentation more heterolactic, inhibited the growth of yeasts, and substantially reduced the amount of spoilage and the associated energy and nutrient losses.

Stay-green ranking and maturity of corn hybrids: 1. Effects on dry matter yield, nutritional value, fermentation characteristics, and aerobic stability of silage hybrids in Florida.

This study determined effects of maturity, stay-green (SG) ranking, and hybrid source on dry matter (DM) yield, nutritive value, fermentation, and aerobic stability of corn hybrids. One high stay-green (HSG) hybrid and one average stay-green (ASG) hybrid with similar relative maturity (117 d) from each of 2 seed companies (Croplan Genetics, St. Paul, MN; Pioneer Hi-Bred International, Des Moines, IA) were grown on 1-× 6-m plots at random locations within each of 4 blocks. The hybrids were harvested at 25, 32, and 37% DM from each plot and separated into thirds for botanical fractionation and analysis, whole-plant chemical analysis, and ensiling. Chopped, whole plants were ensiled (8 kg) in quadruplicate in 20-L mini-silos for 107 d. A split-plot design was used for the study. Yields of whole-plant and digestible DM and concentrations of starch and DM increased with maturity, whereas concentrations of crude protein, water-soluble carbohydrates, and neutral detergent fiber decreased. High SG hybrids had greater DM yield than ASG hybrids when harvested at 25 and 37%, but not 32% DM. Unlike those from Croplan Genetics, the Pioneer HSG hybrid had greater ear and whole-plant DM concentration than their ASG hybrids. Stover moisture and CP concentration were greater among HSG versus ASG hybrids, particularly among Croplan Genetics hybrids. Croplan Genetics HSG hybrids had greater neutral and acid detergent fiber concentrations and lower in vitro DM digestibility in the unensiled whole-plant, the stover, and the silage than their ASG hybrids, whereas contrasting trends were evident for Pioneer hybrids. Silage fermentation indices were largely unaffected by hybrid SG ranking, maturity, or source. Yeast counts increased with maturity and exceeded 10(5) cfu/g; therefore, all silages deteriorated with 26 h, irrespective of treatment. Among the hybrids examined, the optimal maturity for optimizing DM yield and nutritive value of the ASG and HSG hybrids was 37% DM. Stay-green ranking had maturity-dependent effects on the yield of hybrids but had varying effects on nutritional value depending on the source of the hybrid.